6.0 powerstroke crank no start cold

Spring came and now I cant get it to start at all all the PIDs are within spec new ICP sensor FICM power supply and starter. I have a 2005 f250 with a 60l Powerstroke and it ran fine on sat no problems other than a fairly hard start then ran fine afterward.

6 0 Psd Long Crank Cold No Start Hot Sportsmobile Forum

That is why the owners manual says 30 seconds on.

. 38 November 2011 Courtesy Ford Motor Co. The standpipes and dummy plugs in each head for the high pressure oil supply to injectors are the most likely problems. Idles roughtemperatureoccasionallypopping sound and stalls.

Joined Oct 31 2011. Key on engine off the icp is showing 13 volts. If you turn it off and immediately start it the crank time is about 5 to 10 seconds.

If the batteries are 5 years old get new ones. You do not want to start guessing if. It does not sound like it is building enough oil pressure.

Hard Start Cold or Hot Leak in the high pressure oil circuit takes excessive cranking to build minimum ICP pressure see ICP. It idles rough at start and smooths out after warming up although the temperature here is not cold. What I did was switch from Rotella to Valvoline 5W-40 extreme blue synthetic and ordered Hot Shot oil additive direct from Hot Shot.

Call the 800-887-5030 line in the AM and for the sales desk they can see if they have a qualified diesel repair shop with the proper diagnostic to test it. Joined May 8 2017 3 Posts. I found small rip on o-ring on STC Fitting which is located by High Pressure Pump.

Ipr key on engine off is at 145 I believe that is the ipr duty cycle correct. I done diagnostic on f350 truck. 85 and drops to the 30-40s during cranking.

This video is a. Only show this user. Truck starts when cold and no start when hot.

8 Nov 8 2011. Jump to Latest Follow 1 - 7 of 7 Posts. The Buy a Dodge is a cop out and probably not coming from a good diesel mechanic.

The video includes the use of the AutoEnginuity scan tool. This is the first of three parts where I diagnose a hot no start issue on my 2006 60 Powerstroke. 30 seconds or so when cold but idles great and runs well.

The snap-to-connect STC fitting at HP oil pump rarely creates long cranking for long before it fails and results in complete no start until towed and repaired. When I did air leak testing almost no air leak heard from engine oil cap area. Make sure the cables are clean and tight.

I tried to keep the video as short as possible with keeping as much information as possible sorry if it is still too long. So I have a long crank when cold. During cold crank no start icp volts goes to 335 or so.

60 powerstroke crank no start when hot. I was having the same issue with my 06 60. The good thing about a 60.

So what Ive done trying to fix this new Dummy plugs and standpipes new stc fitting. It was a very small air leak. Well yesterday afternoon we were getting ready to leave so I went out to start the truck and it just sat there and cranked and cranked but no start and no.

During cold crank no start while cranking it would jump to 85 and not start that is what lead me to changing the ipr valve. Both must be good and strong or you will also be replacing a starter. Bought an 2006 60 a few months back and it started to have a long crank problem then one day it cranks forever and wont start.

The truck also has no power until it warms up and occasionally it. Tags 60 crank issue powerstroke start. 6 0 Ford Powerstroke Cranks No Start Diagnosising Using A Scangauge X Gauge Part 3 Youtube.

Work performed about 3 weeks prior to this hard start condition was EGR delete kit with up-pipe new. Discussion Starter 1 May 12. I have a 200425 Ford F-250 SuperDuty 60 Power Stroke that has become difficult to start appox.

Truck starts when cold and no start when hot. 60L Power Stroke Engine and Drivetrain. Turns out it was the ICP sensor and a bad fuel pump.

Joined this site last week and went through the archives and did some research. Im working on a 2006 f350 that was cranking but not firing except for once in awhile. 2006 60 cranks no start cold.

From then on it barely starts and if it does its after a super long crank and most of the time cold. No truck is problem free. I have an 07 F250 60l was having no start issues all winter and assumed it was weather related definitely could use a glow plug or two.

Discussion Starter 1 Nov 7 2011. I have an 03 f350 60 powerstroke. Bad cables loose connections old batteries are going to burn out the starter.

Compound Turbo 6 0l Powerstroke Engine Engine Builder Magazine